Coffee picking across parts of Chikkamagaluru and Kodagu has slowed down during the peak harvest season after a large section of migrant labourers returned to West Bengal for the Special Intensive Revision (SIR) verification exercise. The sudden labour shortage has pushed up wage demands from the remaining workers, leaving planters caught between the risk of crop damage if harvesting is delayed and the burden of higher labour costs.

The period between November and March is the peak harvesting season for Robusta coffee, when labour requirement is at its highest and timing is critical, N. Bose Mandanna, former Vice-Chairman, Coffee Board of India, said. He added that coffee cherries have to be picked at the right stage of ripeness, but the process has become a hurdle as many migrant workers have returned to their native districts for over 10 days for the verification process.

Delays threaten quality, yield

If harvesting is delayed, the cherries either over-ripen or dry and fall to the ground, where they get damaged and cannot be used, leading to losses. “The quality goes out immediately if fruit is not picked on time,” he said, adding that when the fruit is harvested at the correct time, the pulp extracted during processing is of the best quality, which gets farmers higher prices, and that any delay directly affects the quantity harvested and the quality of coffee produced. 

Untimely rains

Adding to the disruption caused by workers leaving for the SIR verification, Abhishiek Ponnappa, a planter and representative of Kodava Coffee Growers, said untimely rainfall in parts of Karnataka and Kerala this January have created a double whammy for the farmers. The rains prevented coffee plants from drying properly, while continuing harvesting under wet conditions risks damaging the plants and affecting the next year’s crop. 

Usually, migrant workers return to their home states either before the coffee harvest begins or after it ends in March. This time, however, labour shortage was a challenge throughout January due to SIR verification, as workers began receiving notifications and left within extreme short notice, Harish Maharishi, who owns a plantation in Mudigere, Chikkamagaluru said.   

Local workers tied to tourism

In Chikkamagaluru and Kodagu, local workers are largely unavailable in plantation areas, as the growth of tourism has absorbed much of the local workforce, leaving coffee estates heavily dependent on migrant labour, planters said.  

Producing one tonne of Robusta green coffee beans requires about 4,500–4,700 kg of coffee fruit. In Indian conditions, an average acre of Robusta yields around 600–700 kg of fruit. At the usual harvesting rate of ₹5 per kg, and assuming a picker harvests about 200 kg a day, it would take roughly 15–17 labourers to harvest one acre of a Robusta plantation, Mr. Mandana explained.  

Rising wages

Another concern during large-scale labour shortages is a sharp increase in wage demands, planters said. 

Under regular conditions, Robusta pickers are paid ₹4–₹5 per kg because the variety allows large volumes to be harvested in a day. The coffee picked by each worker is weighed, and wages are calculated accordingly. An average worker, Mr. Mandana explained, earns ₹476.11 a day, but those who pluck 200–250 kg can earn ₹800–₹1,200 in a single day. When labour becomes scarce, workers, as planters said they are witnessing now, demand higher rates of ₹7–₹8 per kg, which sharply increases the cultivation cost, leading to a difference of at least ₹600 per worker per day for the same quantity of coffee picked.

source: http://www.thehindu.com / The Hindu / Home> News> India> Karnataka / by Rishita Khanna / January 31st, 2026